Baja MarineOwner’s Manual30 OutlawOwner’s Manual Part Number: MRP 1813655© Baja Marine Corporation 2006RSpeed changes you.TM.
viii30 Outlaw® Information in this publication is based upon the latest product specications available at printing. Baja® Marine Corporation reserves
30 Outlaw®1.1SeCtiOn 1 • SaFetySAFE boating means:• Knowing the limitations of your boat• Following the "Rules of the Road"• Keeping a sh
30 Outlaw®1.2SeCtiOn 1 • SaFety2. leGallY ManDaTeD MiniMuM requireD equipMenTConsult your national or state boating law enforcement agency.The
30 Outlaw®1.3SeCtiOn 1 • SaFetySymptoms of carbon monoxide poisoning are dizziness, ears ringing, headaches, nausea, and unconsciousness. Get fresh a
30 Outlaw®1.4SeCtiOn 1 • SaFetyEven strong swimmers can tire quickly in the water and drown due to exhaustion, hypothermia, or both. The buoyancy p
30 Outlaw®1.5SeCtiOn 1 • SaFetyDrugs and/or alcohol impair the operator's ability to control the boat safely.Death or serious injury can r
30 Outlaw®1.6SeCtiOn 1 • SaFetyWhen engine is running, keep passengers away from areas not designed for riding, such as seat backs, bow, gunwales, t
30 Outlaw®1.7SeCtiOn 1 • SaFetyDeath or serious injury can result if you fail to observe these safety rules:• Anyone who controls the boat must have
30 Outlaw®1.8SeCtiOn 1 • SaFetyThe wind speed and wave height specied as the upper limit for your category of boat does not mean that you or your pas
30 Outlaw®1.9SeCtiOn 1 • SaFetyShut engine off if an object is struck or if you run aground.Check for hull leaks and propulsion system damage, befor
Baja Marine COrpOratiOn, 2600 Sea ray Blvd., KnOxville, tn 37914FOr inFOrMatiOn Call 1-865-971-6270 Or Fax 1-865-971-6716internet addreSS: http://www
30 Outlaw®1.10SeCtiOn 1 • SaFetySKIING SIGNALS (FIG. 1.10.1)DIVERS FLAGS(FIG. 1.10.2)CODE ALPHAFLAGSPORT DIVER'SFLAGREDWHITEBLUEWHITEASSISTING OT
30 Outlaw®1.11SeCtiOn 1 • SaFetya. MeDical eMerGencYYou may be far from professional medical help when you are boating. At least two people
30 Outlaw®1.12SeCtiOn 1 • SaFetye. collisions anD leakinGIn the event of collisions and leaking:• Slow down or stop to reduce water intake, unless m
30 Outlaw®1.13SeCtiOn 1 • SaFety! WARNINGA wide variety of components used on this vessel contain or emit chemicals known to the State
30 Outlaw®1.14SeCtiOn 1 • SaFetyNOTICEIt is illegal for any vessel to dump plastic trash anywhere in the ocean or navigable waters of the United State
30 Outlaw®1.15SeCtiOn 1 • SaFety20. nauTical TerMsAbeam – object 90 degrees ( 90°) to center line on either side of boat.Abaft – a point on a boat th
30 Outlaw®1.16SeCtiOn 1 • SaFety21. keY To sYMbols on conTrols & prinTsThese symbols may be found on your controls and gauges and/or used in this
30 Outlaw®1.17SeCtiOn 1 • SaFetyTHIS PAGE INTENTIONALLY LEFT BLANK
30 Outlaw®1.18RSpeed changes you.TM.22. WarninG label locaTionswarning laBel lOCatiOnS(Fig 1.17.1)Located in Owner’s PacketCalifornia Residents OnlyT
30 Outlaw®1.19RSpeed changes you.TM.THIS PAGE INTENTIONALLY LEFT BLANK
i30 Outlaw®Congratulations on becoming the new owner of the world’s #1 performance boat. Baja® Marine Corporation welcomes you into our
30 Outlaw®2.1SeCtiOn 2 • general BOat arrangeMent! CAUTIONDo Not use cleats for lifting.2. passenGer locaTions1. When the boat is moving, all passe
30 Outlaw®2.2SeCtiOn 2 • general BOat arrangeMent3. basic boaT DiMensions anD clearances (uniTeD sTaTes sTanDarD s.a.e.)30 Outlaw specificaTionsOvera
30 Outlaw®2.3SeCtiOn 2 • general BOat arrangeMentbasic boaT DiMensions anD clearances (MeTric)30 Outlaw SpeCiFiCatiOnSOverall Length...
30 Outlaw®2.4SeCtiOn 2 • general BOat arrangeMent6. General Deck laYouTGENERAL DECK LAYOUT(FIG. 2.4.1)FWDREAR(AFT)LEFT(PORT)RIGHT(STBD)Navigation Lig
30 Outlaw®2.5SeCtiOn 2 • general BOat arrangeMent7. DescripTion of Major conTrolsa. Gear shifT anD ThroTTle conTrolThe shift/throttle control unit f
30 Outlaw®2.6SeCtiOn 2 • general BOat arrangeMentc. Trailer sWiTchThe trailer switch (Power Tilt) is not to be confused with the Power Trim function.
30 Outlaw®2.7SeCtiOn 2 • general BOat arrangeMent8. iMporTanT GauGesa. TachoMeTer anD hour MeTerThe tachometer (see Figure 2.7.2) indicates th
30 Outlaw®2.8SeCtiOn 2 • general BOat arrangeMentinSerting the aFt reMOvaBle navigatiOn/anChOr light (lOCated at the Stern OF the BOat) (Fig 2.8.2)ANC
3.130 Outlaw®SeCtiOn 3 • uSing yOur BOat1. pre-launch, launch anD posT-launch checklisTListed below are the critical items you must check and do each
3.2SeCtiOn 3 • uSing yOur BOat30 Outlaw®3. fuelinG The boaTThe fuel ll cap is located on the port side of the boat (Figure 3.2.1). Do not mistake th
ii30 Outlaw® THIS PAGE INTENTIONALLY LEFT BLANK
3.330 Outlaw®SeCtiOn 3 • uSing yOur BOat• Shut off gas burning appliances (gas stove, etc.).• Close all hatches, doors, and keep engine
3.4SeCtiOn 3 • uSing yOur BOat30 Outlaw®• If there are passengers not wearing PFDs, the PFDs must be readily accessible. “Readily accessible” m
3.530 Outlaw®SeCtiOn 3 • uSing yOur BOatit is recommended that the bilge blower run all the time the engine is running.6. Place drive unit in full DO
3.6SeCtiOn 3 • uSing yOur BOat30 Outlaw®10. sTeerinG sYsTeMsa. poWer sTeerinGThe steering system is an enclosed push-pull cable that is hydraulicall
4.130 Outlaw®SeCtiOn 4 • Bilge & underwater gear1. bilGea. fuel & oil spillaGeRegulations prohibit discharging fuel or oily waste in navigab
4.230 Outlaw®SeCtiOn 4 • Bilge & underwater gearExcept for checking the operation of the bilge pump using the ON position, leave the switch in the
4.330 Outlaw®SeCtiOn 4 • Bilge & underwater gearc. iMpacT To sTern DriveThe stern drive can be damaged by impact, either while trailering or boat
4.430 Outlaw®SeCtiOn 4 • Bilge & underwater gearf. Install the thrust washer, propeller, continuity washer, thrust hub, propeller nut retain
30 Outlaw®5.1SeCtiOn 5 • Fuel SySteM1. fuel sYsTeMSection 3 • Using Your Boat contains important fueling information. Take time to read all the
30 Outlaw®5.2SeCtiOn 5 • Fuel SySteM2. fuelinG precauTionsCertain precautions must be carefully and completely observed every time a boat is fu
iii30 Outlaw®intrOduCtiOn1. This ManualThe material within this manual and your Owner’s Manual Packet:• Gives you basic safety information• Describ
30 Outlaw®5.3SeCtiOn 5 • Fuel SySteM• Electrical equipment, including blowers – power off.• Doors, hatches – closed.• Smoking material – extinguish
30 Outlaw®5.4SeCtiOn 5 • Fuel SySteMTHIS PAGE INTENTIONALLY LEFT BLANK
30 Outlaw®6.1RSpeed changes you.TM.SeCtiOn 6 • eleCtriCal SySteMS1. elecTrical sYsTeMs DirecT currenT (Dc)The 12 volt direct current (DC) elect
30 Outlaw®6.2SeCtiOn 6 • eleCtriCal SySteMSRSpeed changes you.TM.Protective terminal covers, such as rubber boots on electrical connections, must b
30 Outlaw®6.3SeCtiOn 6 • eleCtriCal SySteMSRSpeed changes you.TM.Zinc anodes require replacement about every six months, if the boat is operated
30 Outlaw®6.4SeCtiOn 6 • eleCtriCal SySteMSRSpeed changes you.TM.drive puMp(Fig. 6.4.1)TRAILER TRIMBLUE/WHITEREDGREEN/WHITE14 AWG RED14 AWG GREEN14 AW
30 Outlaw®6.5SeCtiOn 6 • eleCtriCal SySteMSRSpeed changes you.TM.drive puMp w/ K-plane triM taBS (Fig. 6.5.1)TRAILER TRIMBLUE/WHITEREDGREEN/WHITETRAIL
30 Outlaw®6.6SeCtiOn 6 • eleCtriCal SySteMSRSpeed changes you.TM.ignitiOn SwitCh (Fig. 6.6.1)TO ENGINERUN CIRCUIT16 AWGPURPLE/BLACK16 AWGPURPLE/BLACKL
6.730 Outlaw®RSpeed changes you.TM.SwitCh panel wire inFOrMatiOn (Fig 6.7.1)PLUG 7BREAKER PANEL2 - Way Deutsch DTP Series PlugPlug DTP06-2SSec
6.830 Outlaw®RSpeed changes you.TM.THIS PAGE INTENTIONALLY LEFT BLANK
iv30 Outlaw® 6. hull iDenTificaTion nuMber (hin)The “Hull Identication Number” located on the starboard side of the transom, is the most impor
30 Outlaw®7.1SeCtiOn 7 • OptiOnS & aCCeSSOrieS1. opTions & accessories locaTionsFigure 7.1.1 shows the location of some of the components. T
30 Outlaw®7.2SeCtiOn 7 • OptiOnS & aCCeSSOrieS2. auToMaTic fire exTinGuisher sYsTeM (opTion)The 30 Outlaw may be equipped with an automati
30 Outlaw®7.3SeCtiOn 7 • OptiOnS & aCCeSSOrieSBimini Top or sunshade must not be used when the vessel speed exceeds 45 MPH. Damage to boat or bim
30 Outlaw®7.4SeCtiOn 7 • OptiOnS & aCCeSSOrieSREFER TO OWNER'S MANUAL PACKET FOR INSTRUCTIONS AND WARRANTY INFORMATION ON DEPTH FINDER.8.
30 Outlaw®7.5SeCtiOn 7 • OptiOnS & aCCeSSOrieSc. vacuflush® heaD (opTion)The VacuFlush® head utilizes a HEAD SYSTEM breaker on the main
8.130 Outlaw®SeCtiOn 8 • required inSpeCtiOn, ServiCe, & MaintenanCeITEMREQUIREDMAINTENANCE/SERVICEREFERENCE SOURCE BEFOREEVERY USEAFTER FIRST20 H
8.2 30 Outlaw®SeCtiOn 8 • required inSpeCtiOn, ServiCe, & MaintenanCesuMMarY GuiDe for inspecTion, service anD MainTenance*Use in salt water or ot
8.330 Outlaw®SeCtiOn 8 • required inSpeCtiOn, ServiCe, & MaintenanCe2. useful service inforMaTionOWNERHOME PORTBOAT NAMEREGISTRATION NUMBER
8.4 30 Outlaw®SeCtiOn 8 • required inSpeCtiOn, ServiCe, & MaintenanCe3. inspecTion, service anD MainTenance proTocola. bilGe areaMany of your bo
8.530 Outlaw®SeCtiOn 8 • required inSpeCtiOn, ServiCe, & MaintenanCe• Check your rst aid kit, making certain it is complete and that
v30 Outlaw®RSpeed changes you.TM.abouT Your express liMiTeD WarranTYBaja Marine offers an Express Limited Warranty on each new Baja purchased through
8.6 30 Outlaw®SeCtiOn 8 • required inSpeCtiOn, ServiCe, & MaintenanCe5. fiTTinG ouT afTer sToraGea. fuel sYsTeMCheck the entire fuel system for
8.730 Outlaw®SeCtiOn 8 • required inSpeCtiOn, ServiCe, & MaintenanCe• Check fuel lines for damage and/or leaks. Make sure that they do not c
8.8 30 Outlaw®SeCtiOn 8 • required inSpeCtiOn, ServiCe, & MaintenanCe8. quick reference checklisTAs the owner/operator of a Baja® Boat, you are r
8.930 Outlaw®SeCtiOn 8 • required inSpeCtiOn, ServiCe, & MaintenanCequick reference checklisT (conT’D)*If engine fails to start, refer to the Engi
8.10 30 Outlaw®SeCtiOn 8 • required inSpeCtiOn, ServiCe, & MaintenanCec. DeparTinGGeneral 1. Passengers/Crew ...
8.1130 Outlaw®SeCtiOn 8 • required inSpeCtiOn, ServiCe, & MaintenanCequick reference checklisT (conT’D) 3. Ignition ...
8.12 30 Outlaw®SeCtiOn 8 • required inSpeCtiOn, ServiCe, & MaintenanCe9. afTer MarkeT equipMenT checklisTAny safety or operational equipment adde
8.1330 Outlaw®SeCtiOn 8 • required inSpeCtiOn, ServiCe, & MaintenanCe10. MainTenance loGFollow the recommended maintenance listed on pages 1 &
8.14 30 Outlaw®SeCtiOn 8 • required inSpeCtiOn, ServiCe, & MaintenanCeMainTenance loG (conT’D) Date Maintenance Description Engine Hours
9.130 Outlaw®SeCtiOn 9 • Care & reFiniShingYour new boat has been designed to provide you with years of enjoyment and satisfaction. In order to m
vi30 Outlaw® 30 Outlaw Owner’S Manual • taBle OF COntentSinTroDucTion1. This Manual ...iii2.
9.2SeCtiOn 9 • Care & reFiniShing30 Outlaw®• Minor scratches and deeper stains that do not penetrate the gelcoat may be removed by light sanding
9.330 Outlaw®SeCtiOn 9 • Care & reFiniShingThe fabric should be cleaned regularly before substances such as dirt, pollen, etc. are allo
9.4SeCtiOn 9 • Care & reFiniShing30 Outlaw®This Page inTenTionally lefT Blank
index30 ouTlaw®indexAAccessories. See Options & Accessories LocationsBBilge 4.1Blower 4.2Maintenance 4.2, 8.4Pump 4.1Boarding 3.3Breakers.
index 30 ouTlaw®This Page inTenTionally lefT Blank
vii30 Outlaw®secTion 5 • fuel sYsTeM1. Fuel System...............5.12. Fueling Precautions .....
Comments to this Manuals